Role of Alicyclobacillus acidoterrestris in the development of a disinfectant taint in shelf-stable fruit juice.

AIMS: This study was undertaken to identify the bacterium and metabolic products contributing to a disinfectant taint in shelf-stable fruit juice and to determine some of the growth conditions for the organism. METHODS AND RESULTS: Microbiological examination of tainted and untainted fruit juice drinks detected low numbers of acid-dependent, thermotolerant, spore-forming bacteria in the tainted juices only. The presence of omega-cyclohexyl fatty acids was confirmed in two of the isolates by cell membrane fatty acid analysis. The isolates were subsequently identified as Alicyclobacillus acidoterrestris by partial 16S rDNA sequencing. Studies on the isolates showed growth at pH 2.5-6.0 and 19.5-58 degrees C. Gas chromatography/mass spectrometry (GC/MS) was used to identify and quantify 2,6-dibromophenol (2,6-DBP) and 2,6-dichlorophenol (2,6-DCP) in the tainted juice. Challenge studies in a mixed fruit drink inoculated with the two isolates and the type strain of A. acidoterrestris, incubated at 44-46 degrees C for 4 d, showed the production of both metabolites, which were confirmed and quantified by GC/MS. CONCLUSIONS: The results show that A. acidoterrestris can produce 2,6-DBP and 2,6-DCP in shelf-stable juices. SIGNIFICANCE AND IMPACT OF THE STUDY: This is the first report detailing experimental methodology showing that A. acidoterrestris can produce 2,6-DCP in foods. Control of storage temperatures (to < 20 degrees C) immediately after processing may provide an effective control measure for the fruit juice industry to prevent spoilage by A. acidoterrestris.

Formation of guaiacol in chocolate milk by the psychrotrophic bacterium Rahnella aquatilis.

AIMS: The aim of this study was to identify the causative agent of a smoky/phenolic taint in refrigerated full cream chocolate milk. METHODS AND RESULTS: Microbiological examination of spoiled and unspoiled milk samples from the same processor showed high numbers of the psychrotrophic coliform Rahnella aquatilis in the spoiled samples only. Gas chromatography/mass spectrometry (GC/MS) was used to identify and quantify the taint compound as guaiacol (2-methoxyphenol) in the spoiled milk. Challenge studies in UHT chocolate and white milks inoculated with the isolate and incubated at 4-5 degrees C and 8-9 degrees C for 6 d showed the production of guaiacol in chocolate milk only, which was confirmed and quantified by GC/MS. CONCLUSIONS: The results indicate that if present in refrigerated chocolate milk, Rah. aquatilis can produce guaiacol within the expected shelf-life of the product, even without temperature abuse. SIGNIFICANCE AND IMPACT OF THE STUDY: This is the first report that the coliform Rah. aquatilis can produce guaiacol in refrigerated chocolate milk products.

Heterocyclic volatiles formed by heating cysteine or hydrogen sulfide with 4-hydroxy-5-methyl-3(2H)-furanone at pH 6.5.

The reaction of 4-hydroxy-5-methyl-3(2H)-furanone (HMF) with cysteine or hydrogen sulfide at pH 6.5 for 60 min at 140 degrees C produced complex mixtures of volatile compounds, the majority of these containing either sulfur or nitrogen. Of the 68 compounds detected, 63 were identified, some tentatively, by GC-MS. Among the identified compounds were thiophenes (10), thiophenones (6), thienothiophenes (5), thiazoles (5), trithiolanes (4), pyrazines (6), and oxazoles (4). More compounds were produced in the reaction of HMF with cysteine (63) than were formed in the reaction with hydrogen sulfide (33). In both systems, thiophenones were major reaction products, accounting for 25-36% of the total volatiles formed. Possible reasons for the differences in the composition of the two systems are discussed. The contributions of these reactions, and their products, to the flavor of heated foods are considered.

Brominated anisoles and cresols in the red alga Polysiphonia sphaerocarpa.

The red marine alga Polysiphonia sphaerocarpa was extracted by a simultaneous steam distillation-solvent extraction technique and several brominated compounds were identified by gas chromatography-mass spectrometry. The compounds detected were 2,4-dibromoanisole, 2,4,6-tribromoanisole, 3-bromocresol, 3,5-dibromocresol, 3-bromo-4-hydroxybenzaldehyde, 3,5-dibromo-4-hydroxybenzaldehyde, 2-bromophenol, 4-bromophenol, 2,4-dibromophenol, 2,6-dibromophenol and 2,4,6-tribromophenol. This is the first time brominated anisoles and cresols have been detected in marine algae.

Role of Yersinia intermedia and Pseudomonas putida in the development of a fruity off-flavour in pasteurized milk.

Analysis by gas chromatography-mass spectrometry of pasteurized milk with a fruity (pineapple like) off odour and a sour, rancid and soapy taste indicated the presence of concentrations at microg/ml levels of ethyl butanoate, ethyl hexanoate, ethyl octanoate, ethyl decanoate, octanoic acid, decanoic acid and dodecanoic acid. The off-odour and taste were attributed to the presence of these compounds in the milk. Microbiological examination confirmed that the milk was also contaminated with a series of psychrotrophic bacteria including Yersinia intermedia, Pseudomonas putida and Rahnella aquatilis. Growth of isolates of these bacteria in UHT milk at 23 degrees C for 7 d showed that Yer. intermedia produced significant quantities of the C4-C12 alkanoic acids; Ps. putida produced only small quantities of these acids and Rah. aquatilis produced none. In addition, Yer. intermedia and Ps. putida also produced small but significant quantities of the corresponding ethyl esters. In milk inoculated with both Yer. intermedia and Ps. patida, the quantity of ethyl esters produced was greater than that found in cultures containing only one of the isolates. These studies indicated that Yer. intermedia was the principal source of the alkanoic acids in the tainted milk and that the major producer of the corresponding ethyl esters was Ps. patida. This is the first report that Yer. intermedia and Ps. putida can cause an off-odour or taste in dairy products.

Distribution of bromophenols in species of marine polychaetes and bryozoans from eastern Australia and the role of such animals in the flavor of edible ocean fish and prawns (shrimp).

Sixteen species (44 samples) of marine polychaetes and 10 species (14 samples) of bryozoans from eastern Australia were analyzed by GC/MS for the key seafood flavor components 2- and 4-bromophenol, 2, 4- and 2,6-dibromophenol, and 2,4,6-tribromophenol. All five bromophenols were found in 91% of polychaetes and 64% of bryozoans. The remaining samples all contained at least three bromophenols. 2,4, 6-Tribromophenol was found in all polychaetes and bryozoans and, with few exceptions, was present in the highest concentrations. The total bromophenol content determined on a wet-weight basis varied widely between species: for polychaetes, from 58 ng/g for Australonuphis teres to 8.3 million ng/g for Barantolla lepte, and for bryozoans, from 36 ng/g for Cladostephus spongiosus to 1668 ng/g for Amathia wilsoni. Species of polychaetes with the highest concentrations of bromophenols were all collected from muddy environments. The possible effects that dietary polychaetes and bryozoans have on the ocean-, brine-, or iodine-like flavors of certain seafoods are discussed.

Investigation of the reaction between 4-hydroxy-5-methyl-3(2H)-furanone and cysteine or hydrogen sulfide at pH 4.5.

Reaction of 4-hydroxy-5-methyl-3(2H)-furanone (HMF) with cysteine or hydrogen sulfide at pH 4.5 for 60 min at 140 degrees C produced complex mixtures of volatile compounds, the majority of which contained sulfur. Sixty-nine compounds were identified, some tentatively, by GC/MS. These included disulfides (26), thiols (7), dithiolanones (6), thiophenones (4), dithianones (3), and thienothiophenes (6). The main non-sulfur compounds were 2, 3-pentanedione, 2,4-pentanedione, and 3,4-hexanedione. Both systems produced approximately the same total quantity of volatile compounds, but the reaction containing cysteine gave the larger number of individual compounds, with thiols quantitatively the dominant components. By comparison, the major products formed in the reaction with hydrogen sulfide were the dithiolanones. Reaction pathways are presented for the major products and, where applicable, possible reasons for the differences in composition of the two systems are discussed. The contribution of these reactions, and their products, to the flavor of roasted foods is considered.

Distribution of bromophenols in species of marine algae from eastern Australia.

Forty-nine species (87 samples) of marine macroalgae from eastern Australia were analyzed by GC/MS for the key seafood flavor components 2- and 4-bromophenol, 2,4- and 2,6-dibromophenol, and 2,4, 6-tribromophenol. All five bromophenols were found in 62% of samples, four in 32% of samples, and three in the remaining 6% of samples. 2, 4,6-Tribromophenol was found in all samples and, with few exceptions, was present in the highest concentrations. The total bromophenol content determined on a wet-weight basis varied widely across species from 0.9 ng/g in the green alga Codium fragile to 2590 ng/g in the red alga Pterocladiella capillacea. Species with the highest concentrations of bromophenols were all collected from sites exposed at low tide. The study demonstrates the wide occurrence of bromophenols in marine algae and provides a possible source of such compounds in fish that feed predominantly on ocean plants. The possible effect that dietary marine algae has on the flavor of omnivorous ocean fish is discussed.

Volatiles from interactions of Maillard reactions and lipids.

This article provides current information on the production of volatile compounds from interactions of Maillard reactions and lipids. It includes a brief introduction outlining the Maillard reactions, the Strecker degradation of amino acids, and the oxidation of lipids. It highlights those compounds derived from these reactions that could interact to form volatile flavor components during the processing or cooking of food. The article discusses results obtained from model systems involving interactions between (1) Maillard reaction products and carbonyl compounds, (2) amino acids and carbonyl compounds, (3) amino acids and derivatives of fatty acids, and (4) Maillard reaction products, triglycerides and phospholipids. The qualitative and quantitative effects that triglycerides and phospholipids have on the formation of volatile Maillard products are also discussed. Particular attention is given to those long-chain alkyl heterocyclic compounds formed during these reactions, proposed methods for their formation, and their aromas. The role that such compounds play in food flavors is discussed with reference to those volatile compounds identified in certain cooked foods, such as meat (beef, lamb, and pork), chicken, potatoes (baked, French-fried, and crisps), and beverages (coffee, tea, and cocoa).